Discrete phase numerical study of the effects of nanofluid on the performance characteristics of water chiller

Farrokh, Atie; Mahdi, Miralam

doi:10.22061/jcarme.2026.11821.2585

تعداد نشریات	15
تعداد شماره‌ها	239
تعداد مقالات	2,443
تعداد مشاهده مقاله	4,175,038
تعداد دریافت فایل اصل مقاله	3,046,823

	Discrete phase numerical study of the effects of nanofluid on the performance characteristics of water chiller
Journal of Computational & Applied Research in Mechanical Engineering (JCARME)
مقالات آماده انتشار، پذیرفته شده، انتشار آنلاین از تاریخ 20 مرداد 1405 اصل مقاله (1.32 M)
نوع مقاله: Research Paper
شناسه دیجیتال (DOI): 10.22061/jcarme.2026.11821.2585
نویسندگان
Atie Farrokh؛ Miralam Mahdi^*
Faculty of Mechanical Engineering, Shahid Rajaee Teacher Training University, Tehran, IRAN
تاریخ دریافت: 15 اسفند 1403، تاریخ بازنگری: 13 مرداد 1405، تاریخ پذیرش: 20 مرداد 1405
چکیده
Chillers are among the most widely used air-conditioning systems, and improving their thermal performance can significantly reduce energy consumption. In the present study, the effects of Al₂O₃/water and Al₂O₃–TiO₂/water nanofluids on the performance characteristics of a shell-and-tube chiller evaporator were numerically investigated using an Eulerian-Lagrangian Discrete Phase Model (DPM). The influences of nanoparticle volume fraction, inlet fluid temperature, evaporator temperature, mass flow rate, and number of baffles were examined. Three evaporator configurations with 3, 5, and 7 baffles were considered. The results showed that increasing the number of baffles from 5 to 7 enhanced the overall heat transfer coefficient by 6.94%. The addition of Al₂O₃ nanoparticles increased the overall heat transfer coefficient by 5.8%, while the use of Al₂O₃–TiO₂ hybrid nanoparticles resulted in an enhancement of up to 8.8%. Analysis of the performance evaluation criterion (PEC) indicated that nanoparticle volume fractions up to 0.03 provide favorable thermal performance, with an optimum value around 0.02. The results also demonstrated a significant difference between the DPM and conventional single-phase predictions, with a relative discrepancy of approximately 68% in the estimated heat transfer enhancement under the investigated conditions. The findings confirm the potential of nanofluids, particularly hybrid nanofluids, for enhancing the thermal performance of shell-and-tube chiller evaporators.
کلیدواژه‌ها
Nanoparticles؛ Chiller؛ Evaporator؛ Discrete phase؛ Heat transfer

مراجع
[1] A. Bhattad, J. Sarkar, and P. Ghosh, “Discrete phase numerical model and experimental study of hybrid nanofluid heat transfer and pressure drop in plate heat exchanger,” Int. Commun. Heat Mass Transf., Vol. 91, pp. 262–273, (2018). [2] S. Rahman, S. Issa, Z. Said, M. E. H. Assad, R. Zadeh, and Y. Barani, “Performance enhancement of a solar powered air conditioning system using passive techniques and SWCNT/R-407c nano refrigerant,” Case Stud. Therm. Eng., Vol. 16, p. 100565, (2019). [3] N. Jeyakumar, C. Uthranarayan, and B. Narayanasamy, “Energy conservation in the refrigeration system through improvement of Coefficient of Performance and power consumption reduction using Nanofluids,” Int. J. Ambient Energy, Vol. 43, No. 1, pp. 1120–1126, (2022). [4] A. Bhattad, J. Sarkar, and P. Ghosh, “Improving the performance of refrigeration systems by using nanofluids: A comprehensive review,” Renew. Sustain. Energy Rev., Vol. 82, pp. 3656–3669, (2018). [5] A. A. Vasconcelos, A. O. C. Gómez, E. P. Bandarra Filho, and J. A. R. Parise, “Experimental evaluation of SWCNT-water nanofluid as a secondary fluid in a refrigeration system,” Appl. Therm. Eng., Vol. 111, pp. 1487–1492, (2017). [6] M. S. Ahmed and A. M. Elsaid, “Effect of hybrid and single nanofluids on the performance characteristics of chilled water air conditioning system,” Appl. Therm. Eng., Vol. 163, p. 114398, (2019). [7] M. S. Ahmed, M. R. A. Hady, and G. Abdallah, “Experimental investigation on the performance of chilled-water air conditioning unit using alumina nanofluids,” Therm. Sci. Eng. Prog., Vol. 5, pp. 589–596, (2018). [8] N. Monirimanesh, S. M. Nowee, S. Khayyami, and I. Abrishamchi, “Performance enhancement of an experimental air conditioning system by using TiO2/methanol nanofluid in heat pipe heat exchangers,” Heat and Mass Trans., Vol. 52, pp. 1025–1035, (2016). [9] N. Balaji, P. S. M. Kumar, R. Velraj, and N. Kulasekharan, “Experimental investigations on the improvement of an air conditioning system with a nanofluid-based intercooler,” Arab. J. Sci. Eng., Vol. 40, pp. 1681–1693, (2015). [10] E. Firouzfar, M. Soltanieh, S. H. Noie, and S. H. Saidi, “Energy saving in HVAC systems using nanofluid,” Appl. Therm. Eng., Vol. 31, No. 8–9, pp. 1543–1545, (2011). [11] O. A. Alawi, N. A. C. Sidik, and others, “Applications of nanorefrigerant and nanolubricants in refrigeration, air-conditioning and heat pump systems: A review,” Int. Comm. in Heat and Mass Trans., Vol. 68, pp. 91–97, (2015). [12] M. M. Myat, S. Thu, and T. N. Aung, “A comprehensive review of nanofluids in HVAC&R systems: Applications, performance enhancement and nges,” Sustainability, Vol. 17, No. 16, pp. 7371, (2025). [13] S. Kalsi, A. Kumar, and R. Singh, "A review on hybrid nanofluids for heat transfer: Advancements, synthesis, challenges and applications," Discover Applied Sciences, Vol. 7, No. 698, pp. 1-21, (2025). [14] M. R. Aliyu, M. A. Hamza, and A. Ibrahim, "Performance improvement of an HVAC system using water-based hybrid nanofluids," PLoS One, Vol. 20, No. 5, pp. 1-24, (2025). [15] N. Ali, A. Basem, P. Ghodratallah, P.K. Singh, A. Musa, J. Jasim, R.Ali, H. Rajab, M. Ahmed and A.A. Alizad, "Eulerian-Lagrangian numerical investigation of the fluid flow properties and heat transfer of a nanofluid-cooled micro pin-fin heat sink," J. Taiwan Inst. Chem. Eng., Vol. 164, pp. 105674, (2024). [16] S. Goutam and M. C. Paul, “Discrete phase approach for nanofluids flow in pipe,” in Proc. 2nd Int. Conf. on Advances in Civil, Structural and Mechanical Engineering (CSM), Birmingham, UK, 2014, pp. 99–103. [17] R. D. Selvakumar and S. Dhinakaran, “Heat transfer and particle migration in nanofluid flow around a circular bluff body using a two-way coupled Eulerian-Lagrangian approach,” Int. J. Heat Mass Transf., Vol. 115, pp. 282–293, (2017). [18] M. Bovand, S. Rashidi, G. Ahmadi, and J. A. Esfahani, “Effects of trap and reflect particle boundary conditions on particle transport and convective heat transfer for duct flow-A two-way coupling of Eulerian-Lagrangian model,” Appl. Therm. Eng., Vol. 108, pp. 368–377, (2016). [19] C. T. Crowe, J. N. Chung, and T. R. Troutt, “Particle mixing in free shear flows,” Prog. Energy Combust Sci., Vol. 14, No. 3, pp. 171–194, (1988). [20] J. R. Fessler and J. K. Eaton, “Turbulence modification by particles in a backward-facing step flow,” J. Fluid Mech., Vol. 394, pp. 97–117, (1999). [21] C. K. Chan, H. Q. Zhang, and K. S. Lau, “Numerical simulation of gas-particle flows behind a backward-facing step using an improved stochastic separated flow model,” Comput. Mech., Vol. 27, No. 5, pp. 412–417, (2001).
آمار تعداد مشاهده مقاله: 8 تعداد دریافت فایل اصل مقاله: 4

سامانه مدیریت نشریات علمی. طراحی و پیاده سازی از سیناوب

پیوندهای مفید

آمار

Discrete phase numerical study of the effects of nanofluid on the performance characteristics of water chiller